联系我们

名称:广州空压机匠心厂

电话:xxx

手机:xxx

邮箱:xxx

地址:xxx

新闻动态
空压机维修保养具体执行计划
空压机维修保养具体执行计划
Specific implementation plan for air compressor maintenance
1
one
空气滤清器
Air filter
吸入空气中的灰尘被阻隔在滤清器中,以避免压缩机被过早的磨损和油分离器被阻塞,通常在运转1000个小时或一年后,要更换滤芯,在多灰尘地区,则更换时间间隔要缩短。滤清器维修时必须停机,为了减少停车时间,建议换上一个新的或已清洁过的备用滤芯。
The dust in the inhaled air is blocked in the filter to avoid premature wear of the compressor and blockage of the oil separator. Generally, the filter element should be replaced after 1000 hours or a year of operation. In dusty areas, the replacement interval should be shortened. The filter must be shut down during maintenance. In order to reduce the shutdown time, it is recommended to replace it with a new or cleaned spare filter element.
清洁滤芯步骤如下
Clean the filter element as follows
a. 对着一个平的面轮流轻敲滤芯的两端面,以除去绝大部分重而干的灰沙。
a. Tap the two end faces of the filter element against a flat surface in turn to remove most of the heavy and dry dust.
b. 用小于0.28MPa的干燥空气沿与吸入空气相反的方向吹,喷嘴与折叠纸少相距25毫米,并沿其长度方向上、下吹。
b. Use dry air less than 0.28mpa to blow in the direction opposite to the inhaled air. The nozzle is less than 25mm away from the folded paper, and blow up and down along its length.
c. 如果滤芯上有油脂,则应在溶有无泡沫洗涤剂的温水中洗,在此温水中至少将滤芯浸渍15分钟,并用软管中的干净水拎洗,不要用加热方法使其加速干燥,一只滤芯可洗5次,然后丢弃不可再用。
c. If there is grease on the filter element, it should be washed in warm water with or without foam detergent. Soak the filter element in this warm water for at least 15 minutes, and wash it with clean water in the hose. Do not use heating to accelerate its drying. One filter element can be washed for 5 times, and then discarded for reuse.

联系方式

  1. 名称:广州空压机匠心厂
  2. 电话:xxx
  3. 手机:xxx
  4. 邮箱:xxx
  5. 地址:xxx

版权 ©  广州空压机匠心厂 网址:www.liushuicaomj.cn  推荐:广州空压机,广州永磁变频螺杆机,广州空压机维修保养

网站建设及优化保定遨游网络公司